AEPE  >> Vol. 1 No. 2 (June 2013)

    最小流量阀的数值分析及结构优化
    Numerical Simulation and Structure Optimization of the Minimum Flow Valve

  • 全文下载: PDF(2859KB) HTML    PP.94-99   DOI: 10.12677/AEPE.2013.12016  
  • 下载量: 1,372  浏览量: 4,790  

作者:  

刘贞贞,蒋劲,张立胜,李燕辉:武汉大学动力与机械学院,武汉;
张娜:武汉锅炉集团阀门有限责任公司,武汉

关键词:
最小流量阀数值模拟结构优化Minimum Flow Valve; Numerical Simulation; Structure Optimization

摘要:

对最小流量阀在不同开度下进行了三维数值模拟研究。采用RNG k-epsilon湍流模型封闭N-S方程组以求解阀门内部流场,得到了各个开度下的阀门压力和流速的分布情况。根据阀门的损失系数和流量随开度的变化曲线,研究了阀门的特性。通过对压力分析确定了主要压力损失发生的部位,并提出改进方案。结果表明改进后的阀门,其压力损失得到明显的降低,流体对阀门的冲击也得到明显改善。

Based on three-dimensional numerical simulation results, the minimum flow valve is studied under different opening level. The flow inside the valve was controlled by the Reynolds averaged Navier-Stokes equations together with the continuity equation. The RNG k-epsilon turbulence model was selected to govern the turbulence characteristics. Pressure and velocity distributions in the flow fields were obtained and analyzed under every opening level. The varia- tion curves of the loss coefficient and the flow rate along with the opening level were obtained to study the valve per- formance. The location where the major pressure loss happening was found by analyzing the pressure distribution. Then, the improvement method was proposed. The results of the valve with the new structure show that the pressure loss is decreased and the impaction of the fluid to the valve is alleviated.

文章引用:
刘贞贞, 蒋劲, 张娜, 张立胜, 李燕辉. 最小流量阀的数值分析及结构优化[J]. 电力与能源进展, 2013, 1(2): 94-99. http://dx.doi.org/10.12677/AEPE.2013.12016

参考文献

[1] 蒋旭平, 王海民, 钟方胜, 陈明涛. 迷宫式最小流量阀的流动特性研究[J]. 流体机械, 2009, 37(5): 9-12.
[2] 张雨润, 陈意秋. 调节阀流量特性探索[J]. 阀门, 1997, 3: 15- 19.
[3] 徐锡年, 孙华蔬, 彭宇宇等. 调节阀流量特性理论选用方法和研究[J]. 炼油化工自动化, 1992, 2: 51-59.
[4] 郑建农, 孙叶柱. 进口电站阀门选型分析[J]. 热力发电, 2007, 36(2): 83-84.
[5] 贾青, 陶正良. 从对我国电站调节阀的调研看其现状及发展前景[J]. 水利电力机械, 2005, 27(1): 8-10.
[6] V. B. Kakuzin. Experience in operating the water-injection sys- tem control valves at power station boilers. Thermal Engineering, 2002, 49(4): 300-305.
[7] 阎志敏. 给水泵再循环调节阀的设计与控制[J]. 发电设备, 2008, 23(4): 332-334.
[8] 俞天存. 给水泵最小流量阀选型分析[J]. 青海电力, 2007, 26(1): 53-55.