微生物前沿  >> Vol. 2 No. 1 (March 2013)

温度对“SH-A”工艺处理阿托伐他汀钙制药废水的影响研究
Study on the Influence of Temperature on the “SH-A” Process of Atorvastatin Calcium Pharmaceutical Wastewater

DOI: 10.12677/AMB.2013.21008, PDF, HTML, XML, 下载: 2,353  浏览: 7,463 

作者: 孙锋, 潘大伟, 郑春芳, 王树成:辽宁科技大学,鞍山

关键词: 温度阿托伐他汀钙制药废水SH-ATemperature; Atorvastatin Calcium; Pharmaceutical Wastewater; SH-A

摘要: 本文采用SH-A工艺对处理阿托伐他汀钙制药废水的效果进行了研究,重点研究了温度对SH-A工艺处理阿托伐他汀钙制药废水的影响。实验结果显示:采用SH-A工艺处理阿托伐他汀钙制药废水,能够有效去除废水中的COD-N;温度对SH-A工艺处理阿托伐他汀钙制药废水具有较大的影响。在给定条件下,对于COD,随着系统温度的升高,COD的去除率明显提高,当温度达到35COD去除率达到最大值,继续升高温度,COD去除率有所降低;对于NH4+-N,随着系统温度的升高,其去除率亦明显提高,当温度达到29-N去除率达到100%,继续升高温度,去除率保持不变。根据实验结果,应选择35作为本工艺处理阿托伐他汀钙制药废水的最佳温度。 In this paper, the effect of using SH-A process to treat Atorvastatin Calcium pharmaceutical wastewater is studied. This study mainly focuses on the effect of temperature on the SH-A process. The experimental results show that: the SH-A process has an effective removal of COD and -N; temperature is key factor of the treatment effects. Under the given conditions, the COD removal efficiency improved significantly with the increasing system temperature; the maximum COD removal rate occurred when the temperature reached 35˚C; continued to rise system temperature, COD removal rate decreased. In terms of the -N, with the increase of the system temperature, the removal rate was significantly improved; when the temperature reached 29˚C, -N removal rate reached 100%; continued to rise the temperature, the removal rate remained unchanged. According to the experimental results, the optimal tempera- ture for SH-A process to treat the Atorvastatin Calcium pharmaceutical wastewater should be 35˚C.

文章引用: 孙锋, 潘大伟, 郑春芳, 王树成. 温度对“SH-A”工艺处理阿托伐他汀钙制药废水的影响研究[J]. 微生物前沿, 2013, 2(1): 37-40. http://dx.doi.org/10.12677/AMB.2013.21008

参考文献

[1] 李向东, 冯启言, 于洪锋. 气浮–水解–好氧工艺处理制药废水[J]. 环境工程, 2005, 23(4): 17-18.
[2] 赵庆良, 蔡萌萌, 刘志刚等. 气浮–活性污泥工艺处理制药废水[J]. 中国给水排水, 2006, 22(1): 77-79.
[3] 相会强, 刘良军, 胡宇庭. 水解酸化–两段生物接触氧化工艺处理制药废水[J]. 环境科学与技术, 2005, 28(1): 92-93.
[4] 齐嵘, 杨敏, 马文林. 水解酸化–厌氧–好氧法处理NF合成制药废水研究[J]. 环境污染治理技术与设备, 2004, 5(8): 57-59.
[5] 郑春芳, 单明军, 刘辉等. 阿托伐他汀钙制药废水处理工艺的研究[J]. 辽宁科技大学学报, 2012, 35(1): 28-21.
[6] 单明军.节能型焦化废水脱氮工艺[P].中国专利: 200510047393.2, 2006-5-31.
[7] 陆杰, 徐高田, 张玲. 制药工业废水处理技术[J]. 工业水处理, 2001, 21(10): 1-4.
[8] 单明军, 胡筱敏, 王旭等. SH-A工艺处理焦化废水的工业应用[J]. 环境工程, 2008, 26(1): 30-32.