HJCE  >> Vol. 6 No. 5 (September 2017)

    全再生骨料混凝土强度发展规律试验研究
    Experimental Study on Strength Development of Full-Recycled-Aggregate Concrete

  • 全文下载: PDF(720KB) HTML   XML   PP.498-507   DOI: 10.12677/HJCE.2017.65060  
  • 下载量: 505  浏览量: 1,041   科研立项经费支持

作者:  

姚坤奇,梁 娜,毋欢欢,裴松伟:华北水利水电大学土木与交通学院,河南省生态建材工程国际联合实验室,河南 郑州

关键词:
全再生骨料混凝土再生粗骨料再生细骨料强度发展规律Full-Recycled-Aggregate Concrete (aRAC) Recycled Coarse Aggregate Recycled Fine Aggregate Strength Development

摘要:

本研究采用100%再生细骨料和再生粗骨料配制全再生骨料混凝土,以最大程度利用废旧混凝土再生骨料并取得最佳经济效益。考虑再生骨料预湿处理并变换水灰比和水泥强度进行配合比设计,进行了全再生骨料混凝土工作性能和抗压强度、抗拉强度发展规律的试验研究。结果表明:通过合理的配合比设计和再生骨料预湿处理,全再生骨料混凝土的工作性能和抗压强度均达到设计要求;抗压和抗拉强度的发展几乎在养护龄期56 d之内完成,且抗拉强度的增长低于抗压强度。

This study aims to research and develop a full-recycled-aggregate concrete (aRAC) made of 100% fine and coarse recycled aggregates to get the best benefits by reusing the waste concrete products at the most extent. By changing water-cement ratio and cement strength in mix proportion design of aRAC and the recycled aggregates dealt with pre-wetted process, tests were carried out to study the workability of fresh aRAC and the developments of compressive and tensile strengths of aRAC. Results show that by using proper mix proportion and prewetted recycled aggregates, the workability and compressive strength reached the targets, the development of compressive and tensile strengths was almost finished within 56 days, and the increment of tensile strength was lower relating to that of compressive strength at the same curing age.

文章引用:
姚坤奇, 梁娜, 毋欢欢, 裴松伟. 全再生骨料混凝土强度发展规律试验研究[J]. 土木工程, 2017, 6(5): 498-507. https://doi.org/10.12677/HJCE.2017.65060

参考文献

[1] GB/T 25177-2010. 混凝土用再生粗骨料[S].
[2] GB/T 25176-2010. 混凝土和砂浆用再生细骨料[S].
[3] Nagataki, S., Gokce, A., Saeki, T., et al. (2004) Assessment of Recycling Process Induced Damage Sensitivity of Recycled Concrete Aggregate. Cement and Concrete Research, 34, 965-971.
https://doi.org/10.1016/j.cemconres.2003.11.008
[4] Vivian Tam, W.Y., Gao, X.P. and Tam, C.M. (2005) Microstructural Analysis of Recycled Aggregate Concrete Produced from Two-Stage Mixing Approach. Cement and Concrete Research, 35, 1195-1203.
https://doi.org/10.1016/j.cemconres.2004.10.025
[5] Li, X. (2008) Recycling and Reuse of Waste Concrete in China Part I. Material Behaviour of Recycled Aggregate Concrete. Resources, Conservation and Recycling, 53, 36-44.
https://doi.org/10.1016/j.resconrec.2008.09.006
[6] 肖建庄, 刘琼, 李文贵, 等. 再生混凝土细微观结构和破坏机理研究[J]. 青岛理工大学学报, 2009, 30(4): 24-30.
[7] Xiao, J., Li, W., Fan, Y., et al. (2012) An Overview of Study on Recycled Aggregate Concrete in China (1996-2011). Construction and Building Materials, 31, 364-383.
https://doi.org/10.1016/j.conbuildmat.2011.12.074
[8] Lee, G.C. and Choi, H.B. (2013) Study on Interfacial Transition Zone Properties of Recycled Aggregate by Micro-Hardness Test. Construction and Building Materials, 40, 455-460.
https://doi.org/10.1016/j.conbuildmat.2012.09.114
[9] Seo, D.S. and Choi, H.B. (2014) Effects of the Old Cement Mortar Attached to the Recycled Aggregate Surface on the Bond Characteristics between Aggregate and Cement Mortar. Construction and Building Materials, 59, 72-79.
https://doi.org/10.1016/j.conbuildmat.2014.02.047
[10] Butler, L., West, J.S. and Tighe, S.L. (2013) Effect of Recycled Concrete Coarse Aggregate from Multiple Sources on the Hardened Properties of Concrete with Equivalent Compressive Strength. Construction and Building Materials, 47, 1292-1301.
https://doi.org/10.1016/j.conbuildmat.2013.05.074
[11] Kou, S. and Poon, C. (2015) Effect of the Quality of Parent Concrete on the Properties of High Performance Recycled Aggregate Concrete. Construction and Building Materials, 77, 501-508.
https://doi.org/10.1016/j.conbuildmat.2014.12.035
[12] Lotfi, S., Eggimann, M., Wagner, E., et al. (2015) Performance of Recycled Aggregate Concrete Based on a New Concrete Recycling Technology. Construction and Building Materials, No. 95, 243-256.
[13] Kim, H. and Goulias, D.G. (2015) Shrinkage Behavior of Sustainable Concrete with Crushed Returned Concrete Aggregate. Journal of Materials in Civil Engineering, 27, 04014204.
[14] Katz, A. (2004) Treatment for the Improvement of Recycled Aggregate. Journal of Materials in Civil Engineering, 16, 597-603.
https://doi.org/10.1061/(ASCE)0899-1561(2004)16:6(597)
[15] Shima, H., Tateyashiki, H., Matsuhashi, R., et al. (2005) An Advanced Concrete Recycling Technology and Its Application Assessment through Input-Output Analysis. Journal of Advanced Concrete Technology, 3, 53-67.
https://doi.org/10.3151/jact.3.53
[16] Qiu, J., Tng, D.Q.S. and Yang, E.H. (2014) Surface Treatment of Recycled Concrete Aggregates through Microbial Carbonate Precipitation. Construction and Building Materials, No. 57, 144-150.
[17] Ismail, S. and Ramli, M. (2014) Mechanical Strength and Drying Shrinkage Properties of Concrete Containing Treated Coarse Recycled Concrete Aggregates. Construction and Building Materials, No. 68, 726-739.
[18] Cui, H.Z., Shi, X., Memon, S.A., et al. (2015) Experimental Study on the Influence of Water Absorption of Recycled Coarse Aggregates on Properties of the Resulting Concretes. Journal of Materials in Civil Engineering, 27, 04014138.
[19] Otsuki, N., Miyazato, S. and Yodsudjai, W. (2003) Influence of Recycled Aggregate on Interfacial Transition Zone, Strength, Chloride Penetration and Carbonation of Concrete. Journal of Materials in Civil Engineering, 15, 443-451.
https://doi.org/10.1061/(ASCE)0899-1561(2003)15:5(443)
[20] Corinaldesi, V. and Moriconi, G. (2009) Influence of Mineral Additions on the Performance of 100% Recycled Aggregate Concrete. Construction and Building Materials, No. 23, 2869-2876.
[21] Elhakam, A.A., Mohamed, A.E. and Awad, E. (2012) Influence of Self-Healing, Mixing Method and Adding Silica Fume on Mechanical Properties of Recycled Aggregates Concrete. Construction and Building Materials, No. 35, 421-427.
[22] Brand, A.S., Roesler, J.R. and Salas, A. (2012) Initial Moisture and Mixing Effects on Higher Quality Recycled Coarse Aggregate Concrete. Construction and Building Materials, No. 26, 565-573.
[23] Liang, Y., Ye, Z., Vernerey, F., et al. (2015) Development of Processing Methods to Improve Strength of Concrete with 100% Recycled Coarse Aggregate. Journal of Materials in Civil Engineering, 27, 04014163.
[24] Li, J., Xiao, H. and Zhou, Y. (2009) Influence of Coating Recycled Aggregate Surface with Pozzolanic Powder on Properties of Recycled Aggregate Concrete. Construction and Building Materials, 23, 1287-1291.
[25] Ho, N.Y., Lee, Y.P.K., Lim, W.F., et al. (2013) Efficient Utilization of Recycled Concrete Aggregate in Structural Concrete. Journal of Materials in Civil Engineering, 25, 318-327.
https://doi.org/10.1061/(ASCE)MT.1943-5533.0000587
[26] GB 50010-2010. 混凝土结构设计规范[S].
[27] Fathifazl, G., Razaqpur, A.G., Isgor, O.B., et al. (2011) Creep and Drying Shrinkage Characteristics of Concrete Produced with Coarse Recycled Concrete Aggregate. Cement & Concrete Composites, No. 33, 1026-1037.
[28] Kou, S., Poon, C. and Agrela, F. (2011) Comparisons of Natural and Recycled Aggregate Concretes Prepared with the Addition of Different Mineral Admixtures. Cement & Concrete Composites, No. 33, 788-795.
[29] Yildirim, S.T., Meyer, C. and Herfellner, S. (2015) Effects of Internal Curing on the Strength, Drying Shrinkage and Freeze-Thaw Resistance of Concrete Containing Recycled Concrete Aggregates. Construction and Building Materials, No. 91, 288-296.
[30] Guedes, M., Evangelista, L., Brito De, J., et al. (2013) Microstructural Characterization of Concrete Prepared with Recycled Aggregates. Microscopy and Microanalysis, No. 19, 1222-1230.
https://doi.org/10.1017/S1431927613001463
[31] Evangelista, L., Guedes, M., Brito De, J., et al. (2015) Physical, Chemical and Mineralogical Properties of Fine Recycled Aggregates Made from Concrete Waste. Construction and Building Materials, No. 86, 178-188.
[32] Evangelista, L. and Brito De, J. (2007) Mechanical Behaviour of Concrete Made with Fine Recycled Concrete Aggregates. Cement & Concrete Composites, 29, 397-401.
[33] Evangelista, L. and Brito De, J. (2010) Durability Performance of Concrete Made with Fine Recycled Concrete Aggregates. Cement & Concrete Composites, No. 32, 9-14.
[34] Pereira, P., Evangelista, L. and Brito De, J. (2012) The Effect of Superplasticisers on the Workability and Compressive Strength of Concrete Made with Fine Recycled Concrete Aggregates. Construction and Building Materials, No. 28, 722-729.
[35] Manzi, S., Mazzotti, C. and Bignozzi, M.C. (2013) Short and Long-Term Behavior of Structural Concrete with Recycled Concrete Aggregate. Cement & Concrete Composites, No. 37, 312-318.
[36] Lotfy, A. and Al-Fayez, M. (2015) Performance Evaluation of Structural Concrete using Controlled Quality Coarse and Fine Recycled Concrete Aggregate. Cement & Concrete Composites, No. 61, 36-43.
[37] 李晓克, 郭琦, 赵顺波, 等. 全再生骨料混凝土配合比设计与试验研究[J]. 华北水利水电学院学报(自然科学版), 2013, 34(4): 53-56.
[38] Ding, X., Li, C., Xu, Y., et al. (2016) Experimental Study on Long-Term Compressive Strength of Concrete with Manufactured Sand. Construction and Building Materials, No. 108, 67-73.
[39] Zhao, S., Ding, X., Zhao, M., et al. (2017) Experimental Study on Tensile Strength Development of Concrete with Manufactured Sand. Construction and Building Materials, No. 138, 247-253.
[40] 李晓克, 张晓燕, 李长永, 等. 钢纤维全轻混凝土长期强度和碳化性能试验研究[J]. 土木工程与管理学报, 2017, 34(2): 46-50.
[41] JGJ 55-2011. 普通混凝土配合比设计规程[S].
[42] GB/T 50080-2002. 普通混凝土拌合物性能实验方法标准[S].
[43] GB/T 50081-2002. 普通混凝土力学性能试验方法标准[S].