B2O3添加磷玻璃的制备、介电与力学性能的研究
Investation of Preparation, Dielectric and Mechanical Properties of Phosphate Glass with B2O3 Addition
DOI: 10.12677/MS.2020.103016, PDF,  被引量    国家自然科学基金支持
作者: 周 毅*：太原科技大学材料科学与工程学院，山西省关键基础材料协同创新中心，山西 太原；东北大学材料科学与工程学院，辽宁 沈阳；李永明：国家玻璃器皿产品质量监督检验中心，山西 晋中；孙旭东：东北大学材料科学与工程学院，辽宁 沈阳；大连大学环境与化学工程学院，辽宁 大连；乔 燕：太原理工大学矿业工程学院，山西 太原；王 琨：山西省玻璃陶瓷科学研究所(有限公司)，特种玻璃研究室，山西 太原；赵媛媛, 郑 浩, 赵杉杉, 张成霞, 张雪婷：太原科技大学材料科学与工程学院，山西省关键基础材料协同创新中心，山西 太原
关键词: 磷酸盐玻璃；结构分析；介电性能；力学性能；B2O3添加；Phosphate Glass； Structure Analysis； Dielectric Properties； Mechanical Properties； B2O3 Addition
摘要: 采用熔融快冷法制备了含磷60 mol%的磷酸盐玻璃。系统研究了添加B2O3对磷酸盐玻璃的结构、介电性能与力学性能的影响。添加B2O3使基础磷玻璃的结构变得紧凑，有明显改善介电性能的作用。在电场频率超过50 kHz时，玻璃的介电常数与介电损耗都表现出很好的频率稳定性。同时随着B2O3添加量增加，玻璃的抗折强度与维氏显微硬度也有明显提升。充分表明该体系硼磷酸盐玻璃是一种优异的低介电领域的候选材料。
Abstract: Phosphate glasses containing phosphorus pentoxide of 60 mol% were successfully prepared through melt-quenching technique. Effect of B2O3 addition on structural, dielectric and mechanical properties was investigated. Adding B2O3 made the basic structure of the phosphate glass compact, as well as improving the dielectric properties significantly. As frequency applied exceeded 50 kHz, both the dielectric constant and loss demonstrated good frequency stability. With the increment of B2O3 addition, both the flexural strength and vickers microhardness of the glasses were also improved significantly. It is indicated that phosphate glass in this system is an excellent candidate in the low dielectric application.
文章引用：周毅, 李永明, 孙旭东, 乔燕, 王琨, 赵媛媛, 郑浩, 赵杉杉, 张成霞, 张雪婷. B2O3添加磷玻璃的制备、介电与力学性能的研究[J]. 材料科学, 2020, 10(3): 127-134. https://doi.org/10.12677/MS.2020.103016

参考文献

[1] Ogawa, H., Kan, A., Ishihara, S. and Higashida, Y. (2003) Crystal Structure of Corundum Type Mg4(Nb2-xTax)O9 Microwave Dielectric Ceramics with Low Dielectric Loss. Journal of the European Ceramic Society, 23, 2485-2488. [Google Scholar] [CrossRef] 
[2] Mӧncke, D. (2015) Doris Ehrt-Glass Chemical Research in the Spirit of Otto Schott. Physics and Chemistry of Glasses: European Journal of Glass Science and Technology Part B, 56, 235-247. [Google Scholar] [CrossRef] 
[3] He, D.F. and Gao, C. (2018) Effect of Boron on Crystallization, Microstructure and Dielectric Properties of CBS Glass-Ceramics. Ceramics International, 44, 16246-16255. [Google Scholar] [CrossRef] 
[4] Hench, L.L. (2006) The Story of Bioglass. Journal of Materials Science-Materials in Medicine, 17, 967-978. [Google Scholar] [CrossRef] [PubMed]
[5] Brow, R.K. (2000) Review: The Structure of Simple Phosphate Glasses. Journal of Non-Crystalline Solids, 263, 1-28. [Google Scholar] [CrossRef] 
[6] Ehrt, D. (1996) Redox Behaviour of Polyvalent Ions in the Ppm Range. Journal of Non-Crystalline Solids, 196, 304-308. [Google Scholar] [CrossRef] 
[7] Lippma, E., Magi, M., Samoson, A. and Engelhardt, G. (1980) Structural Studies of Silicates by Solid-State High-Resolution 29 Si NMR. Journal of the American Chemistry Society, 102, 4889-4893. [Google Scholar] [CrossRef] 
[8] Li, X.Y., Lu, A.X. and Yang, H.M. (2014) Structure of ZnO-Fe2O3-P2O5 Glasses Probed by Raman and IR Spectroscopy. Journal of Non-Crystalline Solids, 389, 21-27. [Google Scholar] [CrossRef] 
[9] Abid, M., Et-tabirou, M. and Taibi, M. (2003) Structure and DC Conductivity of Lead Sodium Ultraphosphate Glasses. Materials Science and Engineering B-Solid State Materials for Advanced Technology, 97, 20-24. [Google Scholar] [CrossRef] 
[10] Pemberton, J.E., Latifzahed, L. and Fletcher, J.P. (1991) Raman Spectroscopy of Calcium Phosphate Glasses with Varying CaO Modifier Concentrations. Materials Chemistry, 3, 195-200. [Google Scholar] [CrossRef] 
[11] Linganna, K., Narro-García, R., Manasa, P., Desirena, H., Rosa, E.D. and Jayasankar, C.K. (2018) Effect of BaF2 Addition on Luminescence Properties of Er3+/Yb3+ Co-Doped Phosphate Glasses. Journal of Rare Earths, 36, 58-63. [Google Scholar] [CrossRef] 
[12] Sekhar, A.V., Pavić, L., Milanković, A.M., Kumar, V.R., Reddy, A.S., Raju, G.N. and Veeraiah N. (2020) Dielectric Dispersion and Impedance Spectroscopy of NiO Doped Li2SO4-MgO-P2O5 Glass System. Journal of Alloys and Compounds, 824, Article ID: 153907. [Google Scholar] [CrossRef] 
[13] 赖元明, 梁晓峰, 钱斌, 高龙, 杨世源, 尹光福. 氧化钆对铁磷酸盐玻璃结构的影响[J]. 无机化学学报, 2012, 28(4): 721-726.
[14] Fang, X.Y., Ray, C.S., Milanković, A.M. and Day, D.E. (2001) Iron Redox Equilibrium, Structure and Properties of Iron Phosphate Glasses. Journal of Non-Crystalline Solids, 283, 162-172. [Google Scholar] [CrossRef] 
[15] 刘树江. 掺Yb3+激光玻璃的组成-结构-性能相关性研究[D]: [博士学位论文]. 长沙: 中南大学, 2006.
[16] Filipic, C., Hemberger, J., Kutnjak, Z., Levstik, A. and Loidl, A. (2001) Frequency Dependency of Dielectric Nonlinearity in PMN Relaxor System. Journal of the European Ceramic Society, 21, 1323-1325. [Google Scholar] [CrossRef] 
[17] Shyu, J., and Chen, C. (2003) Sinterable Ferroelectric Glass-Ceramics Containing (Sr, Ba) Nb2O6 Crystals. Ceramics International, 29, 447-453. [Google Scholar] [CrossRef] 
[18] Zhou, Y., Li, Y.M., Qiao, Y. and Feng, R. (2018) Investigation of Structure, Dielectric and Energy-Storage Properties of Lead-Free Niobate Glass and Glass-Ceramics. Journal of Alloys and Compounds, 747, 55-59. [Google Scholar] [CrossRef] 

为你推荐