锂电池电解液池火火焰状态及其振荡频率特性研究
Research on the Oscillation Frequency and Flame Form of Pool Fire of Lithium Battery Electrolyte
摘要: 锂电池作为高效、清洁的新能源被广泛使用，然而在其使用过程中由于电池过热引发的电解液着火问题一直被广泛关注。本文以LBC305-01型电解液为燃料，分别针对6 cm、8 cm和10 cm直径的圆盘，开展不同电解液厚度(1 cm, 1.5 cm)的池火燃烧特性实验研究。通过对火焰状态、火焰振荡现象和火焰振荡频率的分析，结果认为火焰在沸腾阶段有明显的卷吸作用，且火焰呈现拉伸、膨胀、分离、破碎等周期性的振荡变化特性。基于傅里叶变换原理对火焰的振荡频率进行分析，得出电解液池火火焰的振荡频率与直径存在线性变换关系：f = 0.307D − 0.5。
Abstract: The lithium battery is widely used as an efficient and clean new energy. However, electrolyte fire caused by battery overheating has been widely concerned during its use. In this paper, the LBC305-01 electrolyte is used as the fuel to carry out experimental studies on the combustion characteristics of different electrolyte thickness (1 cm, 1.5 cm) for pools with diameters of 6 cm, 8 cm and 10 cm, respectively. Through the analysis of flame form, flame oscillation phenomenon and flame oscillation frequency, the results show that the flame has obvious entrainment in the boiling stage, and the flame presents periodic characteristics of oscillation change such as stretching, expansion, separation, and breaking. Through the analysis of flame oscillation fre-quency based on Fourier transform principle, there exists linear interconversion between the flame oscillation frequency and the diameter of the pool fire of electrolyte: f = 0.307D − 0.5.
文章引用：黄芪, 林国权, 李彦静, 贾静文, 李宏铖, 陈兵, 霍东晨. 锂电池电解液池火火焰状态及其振荡频率特性研究[J]. 安防技术, 2020, 8(1): 5-12. https://doi.org/10.12677/JSST.2020.81002

参考文献

[1] Noh, H.J., Youn, S., Yoon, C.S., et al. (2013) Comparison of the Structural and Electrochemical Properties of Layered Li[NixCoyMnz]O2 (x = 1/3, 0.5, 0.6, 0.7,0.8 and 0.85) Cathode Material for Lithium-Ion Batteries. Journal of Power Sources, 233, 121-130.
[Google Scholar] [CrossRef] 
[2] 付阳阳. 典型锂离子电池和电解液燃烧特性及航空运输环境对其影响机制研究[D]: [博士学位论文]. 合肥: 中国科学技术大学, 2017.
[3] 张旭, 王志, 王旭, 等. 电动飞机锂电池电芯火灾危险性研究[J]. 消防科学与技术, 2016, 35(10): 1479-1481.
[4] Federal Aviation Administration (2004) In-Flight Fires, Advisory Circular 120-80. Department of Transportation, Washington DC.
[5] 张磊, 张永丰, 黄昊, 等. 热过载锂电池失控特性及其早期探测模式研究[J]. 消防科学与技术, 2018, 37(1): 55-58.
[6] 钱新明, 周波. 绝热加速量热仪研究锂离子电池电解液热安全性[J]. 安全与环境学报, 2005, 5(2): 106-111.
[7] Webster, H. (2004) Flammability Assessment of Bulk-Packed, Nonrechargeable Lithium Primary Batteries in Transport Category Aircraft: US Department of Transportation. Federal Aviation Administration, Office of Aviation Research.
[8] Summer, S.M. (2010) Flammability Assessment of Lithium-Ion and Lithium-Ion Polymer Battery Cells Designed for Aircraft Power Usage: US Department of Transportation. Federal Aviation Administration.
[9] 王爽, 杜志明, 张泽林, 韩志跃. 锂离子电池安全性研究进展[J]. 工程科学学报, 2018, 40(8): 901-909.
[10] Roth, E.P. and Doughty, D.H. (2004) Thermal Abuse Perfor-mance of High-Power 18650 Li-Ion Cells. Journal of Power Sources, 128, 308-318.
[Google Scholar] [CrossRef] 
[11] Garcia, M., Nagasubramanian, G., Tallant, D.R., et al. (1999) Instability of Polyvinylidene Fluoride-Based Polymeric Binder in Lithium-Ion Cells: Final Report. Sandia National Labs, Albuquerque, NM; Sandia National Labs, Livermore, CA.
[Google Scholar] [CrossRef] 
[12] Larsson, F. (2014) Assessment of Safety Characteristics for Li-Ion Battery Cells by Abuse Testing. Thesis, Chalmers University of Technology, Göteborg.
[13] 许彬, 张永明, 方俊, 等. 正庚院热释放速率测量与研究[J]. 消防科学与技术, 2006, 25(3): 304-307.
[14] Chivas, C., Bertrand, J.P., Du-plantier, S., et al. (2007) Method to Obtain Large Scale Burning Rate of Liquids with Lab Scale Tests. International Interflam Conference, London, 403- 414.
[15] Linteiis, G.T. and Rafferty, I. (2008) Scale Model Flames for De-termining the Heat Release Rate from Burning Polymers. In: Saito, K., Ed., Progress in Scale Modeling, Springer, Dordrecht, 235-245.
[Google Scholar] [CrossRef] 
[16] Grand, A.F. and Trevino, J. (1996) Flammability Screening and Fire Hazard of Industrial Fluids Using the Cone Calorimeter. In: Totten, G. and Reichel, J., Eds., Fire Resistance of Industrial Fluids, ASTM International, West Conshohocken, PA, 123-129.
[Google Scholar] [CrossRef] 
[17] 黎昌海, 吴迎春, 陆守香, 等. 封闭空间油池火火焰振荡特性研究[J]. 中国科学技术大学学报, 2010, 40(4): 380-386.
[18] Malalasekera, W.M.G., Versteeg, H.K. and Gilchrist, K. (1996) A Review of Research and an Experimental Study on the Pulsation of Buoyant Diffusion Flames and Pool Fires. Fire and Materials, 20, 261-271.
[Google Scholar] [CrossRef] 

为你推荐