分形树状微通道散热性能的数值研究
Numerical Study on Heat Dissipation Performance of Fractal Tree Microchannel
DOI: 10.12677/IJFD.2021.93005, PDF,    科研立项经费支持
作者: 葛秋明*, 陈正明：无锡市志成生化工程装备有限公司，江苏 无锡
关键词: 分形；微通道；高宽比；数值模拟；Fractal； Microchannel； Height-Width Ratio； Numerical Simulation
摘要: 仿生分形树状微通道具有速度分布均匀、传热效率高等特点，目前得到广泛的研究。本文在定横截面积和定水力直径的条件下，根据单条微通道进口截面的不同高宽比(0.333、1、2、4)，各构建出4种分形树状微通道，数值研究了不同Re下微通道的传热、流动以及综合性能。研究发现，微通道的Nu和压降ΔP均随着高宽比的增加而增大。但微通道的最高温度Tmax反而随Nu的增加而增加。其中DJM-0.333和DSL-0.333的Tmax最小，具有更好的散热性能。对综合性能进行分析后，发现不同微通道的COP均随Re的增加而减小，DJM-0.333具有最高的COP，而DJM-4 (DSL-4)的COP最小，且前者比后者平均高37%。进一步得出DJM-0.333具有最佳的散热性能。
Abstract: Biomimetic fractal tree microchannel has been widely studied because of its uniform velocity dis-tribution and high heat transfer efficiency. Under the condition of constant cross-sectional area and hydraulic diameter, four kinds of fractal tree microchannels were constructed according to the dif-ferent aspect ratios (0.333, 1, 2 and 4) of the entrance section of a single microchannel. The heat transfer, flow and comprehensive performance of the microchannel with different Re were numeri-cally studied. The results showed that the Nu and pressure drop ΔP of the microchannel increased with the increment of aspect ratio. However, the maximum temperature Tmax of the microchannel increased with the increase of Nu. Among them, DJM-0.333 and DSL-0.333 had the smallest Tmax and better heat dissipation performance. After analyzing the comprehensive performance, it was found that the COP of different microchannels all decreased with the increase of Re, DJM-0.333 had the highest COP, while DJM-4 (DSL-4) had the lowest COP, and the former is 37% higher than the latter on average. It was further concluded that DJM-0.333 had the best heat dissipation performance.
文章引用：葛秋明, 陈正明. 分形树状微通道散热性能的数值研究[J]. 流体动力学, 2021, 9(3): 44-56. https://doi.org/10.12677/IJFD.2021.93005

参考文献

[1] Tuckerman, D.B. and Pease, R.F.W. (1981) High-Performance Heat Sinking for VLSI. Electron Device Letters, 2, 126-129. [Google Scholar] [CrossRef] 
[2] 徐国强, 王梦, 吴宏, 等. Y形构形微通道流动换热特性的数值分析[J]. 北京航空航天大学学报, 2009, 35(3): 313-317.
[3] 侯亚丽, 汪建文. 几何参数对矩形微通道内流体流动特性的影响[J]. 排灌机械工程学报, 2015(5): 417-421.
[4] Zhang, C.P., Lian, Y.F., Yu, X.F., et al. (2013) Numerical and Experimental Studies on Laminar Hydrodynamic and Thermal Characteristics in Fractal-Like Mi-crochannel Networks. Part A: Comparisons of Two Numerical Analysis Methods on Friction Factor and Nusselt Num-ber. International Journal of Heat and Mass Transfer, 66, 930-938. [Google Scholar] [CrossRef] 
[5] Zhang, C.P., Lian, Y.F., Yu, X.F., et al. (2013) Nu-merical and Experimental Studies on Laminar Hydrodynamic and Thermal Characteristics in Fractal-Like Microchannel Networks. Part B: Investigations on the Performances of Pressure Drop and Heat Transfer. International Journal of Heat and Mass Transfer, 66, 939-947. [Google Scholar] [CrossRef] 
[6] Zhang, C.P., Lian, Y.F., Hsu, C.H., et al. (2015) In-vestigations of Thermal and Flow Behavior of Bifurcations and Bends in Fractal-Like Microchannel Networks: Second-ary Flow and Recirculation Flow. International Journal of Heat and Mass Transfer, 85, 723-731. [Google Scholar] [CrossRef] 
[7] Rubio-Jimenez, C.A., Hernandez-Guerrero, A., Cer-vantes, J.G., et al. (2016) CFD Study of Constructal Microchannel Networks for Liquid-Cooling of Electronic Devices. Applied Thermal Engineering, 95, 374-381. [Google Scholar] [CrossRef] 
[8] 谭慧, 宗宽, 熊长武, 等. 叶脉型微通道热沉设计及散热特性分析[J]. 工程设计学报, 2019, 26(4): 113-119.
[9] Liang, L.X., Hou, J.B., Fang, X.J., et al. (2019) Flow Characteristics and Heat Transfer Performance in a Y-Fractal Mini/Microchannel Heat Sink. Case Studies in Thermal Engineering, 15, Article ID: 100522. [Google Scholar] [CrossRef] 
[10] Huang, P.N., Dong, G.P., Zhong, X.N., et al. (2020) Numerical Investigation of the Fluid Flow and Heat Transfer Characteristics of Tree-Shaped Microchannel Heat Sink with Variable Cross-Section. Chemical Engineering and Processing—Process Intensification, 147, Article ID: 107769. [Google Scholar] [CrossRef] 
[11] 石瀚楠, 谢志辉, 孙丰瑞, 等. 树状脉管圆盘热沉的传热分析与构形设计[J]. 工程热物理学报, 2019, 40(7): 140-145.
[12] Celata, G.P. and Carey, V.P. (2000) Heat Transfer and Transport Phenomena in Microscale. Proceedings of the International Conference on Heat Transfer and Transport Phenomena in Microscale, Banff, 15-20 October 2000.
[13] 李聪. 电子器件冷却用分形微通道的构造及其散热性能研究[D]: [硕士学位论文]. 湘潭: 湘潭大学, 2019.
[14] Qu, W.L. and Mudawar, I. (2002) Experimental and Nu-merical Study of Pressure Drop and Heat Transfer in a Single-Phase Micro-Channel Heat Sink. International Journal of Heat and Mass Transfer, 45, 2549-2565. [Google Scholar] [CrossRef] 
[15] Chai, L., Xia, G.D. and Wang, H.S. (2016) Parametric Study on Thermal and Hydraulic Characteristics of Laminar Flow in Microchannel Heat Sink with Fan-Shaped Ribs on Side-walls—Part 1: Heat Transfer. International Journal of Heat and Mass Transfer, 97, 1069-1080. [Google Scholar] [CrossRef] 

为你推荐