水平气井斜井段气流携液分析研究
Analysis and Research on Air Flow and Liquid Carrying in Inclined Section of Horizontal Gas Well
DOI: 10.12677/JOGT.2022.442015, PDF,   
作者: 王小玮, 陈明珠：中国石油新疆油田公司工程技术研究院，新疆 克拉玛依；祁丽莎：中国石油新疆油田公司勘探开发研究院，新疆 克拉玛依；马文敏, 姜 明, 王修武*：昆明理工大学化学工程学院，云南 昆明
关键词: 水平气井斜井段；持液率；临界携液；气液两相流型流态；Inclined Section of Horizontal Gas Well； Liquid Holdup Rate； Critical Liquid； Gas-Liquid Two-Phase Flow Pattern
摘要: 水平气井斜井段气流携液最为困难，气流携液状况较为复杂，现有携液模型不够准确。鉴于此，本文利用室内多相管流实验及理论分析相结合的方法，针对斜井段气流携液开展了特定研究。研究发现，斜井段气流携液处于段塞流向扰动流转变的临界状态；井筒中持液率随产气量的减小而增大，随管倾角的增加而呈现先增大后减小的趋势；建立的斜井段临界新模型经现场验证，其预测准确度高，平均误差小(2.16%)。本文的研究可为水平气井实施排液采气工艺措施提供科学依据，为实际生产过程提供一定的理论参考。
Abstract: It is the most difficult for the air flow to carry liquid in the inclined section of a horizontal gas well. The air flow and liquid carrying situation are more complicated, and the existing liquid carrying model is not accurate enough. In view of this, this paper uses the method of indoor multiphase pipe flow experiment and theoretical analysis to carry out specific research on air flow and liquid carrying in the inclined well section. The study found that the gas flow in the inclined well section is in the critical state of the transition from slug flow to disturbance flow; the liquid holdup in the wellbore increases with the decrease of gas production, and shows a trend of first increasing and then decreasing with the increase of pipe dip.; the new model for criticality of the inclined well section has been verified on site, and its prediction accuracy is high, and the average error is small (2.16%). The research in this paper can provide a scientific basis for the implementation of liquid drainage and gas recovery technology measures in horizontal gas wells, and provide a certain theoretical reference for the actual production process.
文章引用：王小玮, 祁丽莎, 陈明珠, 马文敏, 姜明, 王修武. 水平气井斜井段气流携液分析研究[J]. 石油天然气学报, 2022, 44(2): 111-126. https://doi.org/10.12677/JOGT.2022.442015

参考文献

[1] 汪毅. 干热岩地层水平井自循环地热开采机理研究[D]: [硕士学位论文]. 东营: 中国石油大学(华东), 2019.
[2] 徐晓峰, 傅春梅. 川西气田水平井井身结构对排水采气的影响[J]. 新疆石油天然气, 2013, 9(1): 23-27.
[3] 李维轩, 宋琳, 席传明, 等. 新疆玛湖油田致密砾岩超长水平段水平井钻完井技术[J]. 新疆石油天然气, 2021, 17(4): 86-91.
[4] 宋培久, 周瑞斌. 排水采气工艺及其发展趋势[J]. 云南化工, 2018, 45(2): 131.
[5] 陈希, 刘蕊宁, 谢勃勃, 等. 考虑层理缝的页岩油藏压裂水平井产能模型[J]. 新疆石油天然气, 2022, 18(1): 73-79.
[6] 沈伟伟, 邓道明, 刘乔平, 等. 天然气管道积液临界气速预测模型研究进展[J]. 油气储运, 2020, 39(10): 1109- 1115.
[7] 窦金宝. 气井井筒气液两相流动特性及临界携液模型研究[D]: [硕士学位论文]. 西安: 西安石油大学, 2020.
[8] 汪政明, 王晓磊, 张赟新, 等. 预测盆5凝析气藏气井临界携液量方法及应用[J]. 新疆石油天然气, 2014, 10(3): 77-82.
[9] Veeken, K., Hu, B. and Schiferli, W. (2010) Gas-Well Liquid-Loadingfield-Data Analysis and Multiphase-Flow Modeling. SPE Production & Operations, 25, 275-284. [Google Scholar] [CrossRef] 
[10] 江健, 邹一锋, 周兴付, 等. 水平井临界携液流量预测及其应用研究[J]. 天然气与石油, 2012, 30(3): 45-48.
[11] 杨功田, 邹一锋, 周兴付, 等. 斜井携液临界流量模型研究[J]. 油气藏评价与开发, 2012, 2(1): 33-36.
[12] Gurner, M., Pereyra, E., Sarica, C. and Torres, C. (2015) An Experimental Study of Low Liquid Loading in Inclined Pipes from 90˚ to 45˚. SPE Production and Operations Symposium, Oklahoma City, 1-5 March 2015, SPE-173631-MS.
[13] Taitel, Y. and Dukler, A.E. (1976) A Model for Predicting Flow Regime Transitions in Horizontal and Near Horizontal Gas-Liquid Flow. AIChE Journal, 22, 47-55. [Google Scholar] [CrossRef] 
[14] Barnea, D., Shoham, O., Taitel, Y. and Dukler, A.E. (1985) Gas Liquid Flow in Inclined Tubes: Flow Pattern Transitions for Upward Flow. Chemical Engineering Science, 40, 131-136. [Google Scholar] [CrossRef] 
[15] 周兴付, 杨功田, 高升, 王守信. 川西气田大斜度井临界携液模拟实验研究[J]. 钻采工艺, 2012, 35(4): 47-49+124-125.
[16] 高升. 定向气井携液临界流量实验及应用[D]: [硕士学位论文]. 成都: 西南石油大学, 2012.
[17] 戚志林, 雷登生, 李志军, 等. 倾斜气井井筒携液临界流量计算方法[J]. 大庆石油地质与开发, 2012, 31(1): 118-120.
[18] Gomez, L., Shoham, O., Schmidt, Z., et al. (1999) A Unified Mechanistic Model for Steady-State Two-Phase Flow in Wellbores and Pipelines. SPE Annual Technical Conference and Exhibition, Houston, 3-6 October 1999, SPE-56520-MS. [Google Scholar] [CrossRef] 
[19] Bendiksen, K.H. (1984) An Experimental Investigation of the Motion of Long Bubbles in Inclined Tubess. International Journal of Multiphase Flow, 10, 467-483. [Google Scholar] [CrossRef] 
[20] Alves, I. (1991) Slug Flow Phenomena in Inclined Pipes. University of Tulsa, Tulsa.
[21] Brötz, W. (1954) Uber die Vorausberechnung der Absorptionsgeschwindigkeit von Gasen in stromenden Flussigkeitss- chichten. Chemie Ingenieur Technik, 26, 470-478. [Google Scholar] [CrossRef] 
[22] Chokshi, R. (1994) Prediction of Pressure Drop and Liquid Holdup in Vertical Two-Phase Flow Tubing. University of Tulsa, Tulsa.
[23] Kaya, A.S., Chen, X.T., Sarica, C., et al. (2000) Investigation of Transition from Annular to Intermittent Flow in Pipesg. Journal of Energy Resources Technology, 122, 22-28. [Google Scholar] [CrossRef] 
[24] Gomeza, L.E., Shohama, O. and Taitelb, Y. (2000) Prediction of Slug Liquid Holdup: Horizontal to Upward Vertical Flow. International Journal of Multiphase Flow, 26, 517-521. [Google Scholar] [CrossRef] 
[25] Beggs, D.H. and Brill, J.P. (1973) An Experimental Study of Two-Phase Flow in Inclined Pipes. Journal of Petroleum Technology, 25, 607-617. [Google Scholar] [CrossRef] 
[26] Mukherjee, H. and Brill, J.P. (1985) Pressure Drop Correlations for In-clined Two-Phase Flow. Journal of Energy Resources Technology, 107, 549-554. [Google Scholar] [CrossRef] 
[27] 王修武, 罗威, 刘捷, 等. 油气水多相管流预测方法研究[J]. 特种油气藏, 2018, 25(2): 70-75.