石墨烯增强铝基复合材料研究进展
Research Progress of Graphene Reinforced Aluminum Matrix Composites
DOI: 10.12677/MS.2022.127081, PDF,  被引量    科研立项经费支持
作者: 张 园, 朱晓松, 赵志伟, 高 飞：河北工程大学材料科学与工程学院，河北 邯郸；刘晓艳*：河北工程大学材料科学与工程学院，河北 邯郸；河北省稀土永磁材料与应用工程研究中心，河北 邯郸；武常生：新兴铸管股份有限公司，河北 邯郸
关键词: 石墨烯；铝基复合材料；制备方法；界面；定向排列；Graphene； Aluminum Matrix Composites； Preparation Method； Interface； Directional Alignment
摘要: 自从石墨烯被发现以来，由于其独特的性能优势，是铝基复合材料中理想的增强体材料。随着对石墨烯增强铝基复合材料研究的不断深入，其制备工艺和方法越来越多。同时，铝基复合材料中存在的问题逐一展露，包括增强体团聚、界面结合不佳和严重界面反应等都会严重影响铝基复合材料的最终性能，制约石墨烯增强铝基复合材料的发展。本文综述了石墨烯增强铝基复合材料国内外研究现状，阐述了增强体氧化石墨烯、还原氧化石墨烯和石墨烯纳米片的选择，介绍了石墨烯增强铝基复合材料的制备方法，分析了目前石墨烯与铝基体的界面问题，以及石墨烯在基体中的定向排列，最后简要阐述了石墨烯增强铝基复合材料未来的研究方向。
Abstract: Since its discovery, graphene has become an ideal reinforcement material for aluminum matrix composites due to its unique performance advantages. With the development of the research on graphene reinforced aluminum matrix composites, more and more preparation technologies and methods have been found. Meanwhile, the existing problems are also revealed one by one, such as reinforcement agglomeration, poor interfacial bonding and severe interface reactions, and so on. All these problems can seriously affect the final performances of aluminum matrix composites and restrict the development of graphene reinforced aluminum matrix composites. In this paper, the current research status of graphene reinforced aluminum matrix composites at home and abroad were summarized, elaborates the selection among reinforced graphene oxide, reduced graphene oxide and graphene nanosheets, and the preparation method of graphene reinforced aluminum matrix composites were introduced. In addition, the interfacial issue between graphene and aluminum matrix and the directional alignment of graphene in the matrix were analyzed. Finally, the future research direction of graphene reinforced aluminum matrix composites was briefly expounded.
文章引用：张园, 刘晓艳, 武常生, 朱晓松, 赵志伟, 高飞. 石墨烯增强铝基复合材料研究进展[J]. 材料科学, 2022, 12(7): 731-740. https://doi.org/10.12677/MS.2022.127081

参考文献

[1] 齐浩天. 石墨烯增强铝基复合材料的微观组织及磨损性能研究[D]: [硕士学位论文]. 沈阳: 沈阳理工大学, 2021.
[2] Geim, A.K. (2009) Graphene: Status and Prospects. Science, 324, 1530-1534. [Google Scholar] [CrossRef] [PubMed]
[3] Paredes, J.I., Villar-Rodil, S., Martínez-Alonso, A. et al. (2008) Graphene Oxide Dispersions in Organic Solvents. Langmuir, 24, 10560-10564. [Google Scholar] [CrossRef] [PubMed]
[4] 陈骥. 氧化石墨烯的制备及结构控制[D]: [博士学位论文]. 北京: 清华大学, 2016.
[5] Bahri, A., Askarnia, R., Esmaeilzadeh, J. and Roueini Fardi, S. (2021) Mechanical and Electrochemical Behaviors Assessments of Aluminum-Graphene Oxide Composites Fabricated by Mechanical Milling and Repetitive Upsetting Extrusion. Journal of Composites and Compounds, 3, 152-158. [Google Scholar] [CrossRef] 
[6] Li, Z., Guo, Q., Li, Z.Q., et al. (2015) Enhanced Mechanical Properties of Graphene (Reduced Graphene Oxide)/Aluminum Composites with a Bioinspired Nanolaminated Structure. Nano Letters, 15, 8077-8083. [Google Scholar] [CrossRef] [PubMed]
[7] Li, D.S., Ye, Y., Liao, X.J. and Qin, Q.H. (2018) A Novel Method for Preparing and Characterizing Graphene Nanoplatelets/Aluminum Nanocomposites. Nano Research, 11, 1642-1650. [Google Scholar] [CrossRef] 
[8] 刘洋, 李雷, 历长云, 许磊, 米国发. 高强高导铝-石墨烯复合材料研究进展[J]. 粉末冶金技术, 2021, 39(4): 358-365.
[9] Han, T.L., Wang, F.C., Li, J.J., et al. (2021) Simultaneously Enhanced Strength and Ductility of Al Matrix Composites through the Introduction of Intragranular Nano-Sized Graphene Nanoplates. Composites Part B: Engineering, 212, Article ID: 108700. [Google Scholar] [CrossRef] 
[10] Gao, X., Yue, H.Y., Guo, E.J., et al. (2016) Preparation and Tensile Properties of Homogeneously Dispersed Graphene Reinforced Aluminum Matrix Composites. Materials & Design, 94, 54-60. [Google Scholar] [CrossRef] 
[11] Wang, C.Y., Su, Y.S., Ouyang, Q.B., et al. (2020) Enhanced Through-Plane Thermal Conductivity and Mechanical Properties of Vertically Aligned Graphene Nanoplatelet@Graphite Flakes Reinforced Aluminum Composites. Diamond and Related Materials, 108, Article ID: 107929. [Google Scholar] [CrossRef] 
[12] Kumar, R.V., Harichandran, R., Vignesh, U., et al. (2020) Influence of Hot Extrusion on Strain Hardening Behavior of Graphene Platelets Dispersed Aluminum Composites. Journal of Alloys and Compounds, 855, Article ID: 157448. [Google Scholar] [CrossRef] 
[13] 张哲. 搅拌铸造GNPs/2024 Al复合材料制备及性能研究[D]: [硕士学位论文]. 哈尔滨: 哈尔滨工业大学, 2019.
[14] 马会中, 赵志凯, 夏慧敏, 张兰. 石墨烯增强铝基复合材料的制备与性能研究[J]. 热加工工艺, 2020, 49(20): 75-79.
[15] Khoshghadam-Pireyousefan, M., Rahmanifard, R., Orovcik, L., et al. (2020) Application of a Novel Method for Fabrication of Graphene Reinforced Aluminum Matrix Nanocomposites: Synthesis, Microstructure, and Mechanical Properties. Materials Science and Engineering: A, 772, Article ID: 138820. [Google Scholar] [CrossRef] 
[16] 梁建权, 赵宇宏, 陈利文, 张婷, 李沐奚, 侯华, 等. 石墨烯纳米片增强铝基复合材料的制备及研究[J]. 特种铸造及有色合金, 2019, 39(6): 652-656.
[17] 王天琦, 李鹏旭, 陈彩英, Cai, R., 王维, 孟庆实. 石墨烯增强铝基复合材料硬度的研究[J]. 沈阳航空航天大学学报, 2021, 38(4): 26-34.
[18] 常庆明, 李宗伦, 许芳宇. 石墨烯增强铝基复合材料的制备及性能研究[J]. 热加工工艺, 2022(14): 70-73+77.
[19] Xu, Z.Y., Li, C.J., Wang, Z., et al. (2020) Balancing the Strength and Ductility of Graphene Oxide-Carbon Nanotube Hybrid Reinforced Aluminum Matrix Composites with Bimodal Grain Distribution. Materials Science and Engineering: A, 796, Article ID: 140067. [Google Scholar] [CrossRef] 
[20] Mohammed, A.S., Alahmari, T.S., Laoui, T., et al. (2021) Mechanical and Thermal Evaluation of Aluminum Hybrid Nanocomposite Reinforced with Alumina and Graphene Oxide. Nanomaterials, 11, Article No. 1225. [Google Scholar] [CrossRef] [PubMed]
[21] Zhang, J.S., Liu, Q., Yang, S.F., et al. (2020) Microstructural Evolution of Hybrid Aluminum Matrix Composites Reinforced with SiC Nanoparticles and Graphene/Graphite Prepared by Powder Metallurgy. Progress in Natural Science: Materials International, 30, 192-199. [Google Scholar] [CrossRef] 
[22] Zhang, Y.Y. and Li, X.D. (2017) Bioinspired, Graphene/Al2O3 Doubly Reinforced Aluminum Composites with High Strength and Toughness. Nano Letters, 17, 6907-6915. [Google Scholar] [CrossRef] [PubMed]
[23] Guan, R., Wang, Y., Zheng, S., et al. (2019) Fabrication of Aluminum Matrix Composites Reinforced with Ni-coated Graphene Nanosheets. Materials Science and Engineering: A, 754, 437-446. [Google Scholar] [CrossRef] 
[24] Zhou, W., Mikulova, P., Fan, Y., et al. (2019) Interfacial Reaction Induced Efficient Load Transfer in Few Layer Graphene Reinforced Al Matrix Composites for High-Performance Conductor. Composites Part B: Engineering, 167, 93-99. [Google Scholar] [CrossRef] 
[25] Li, M., Zhang, Z., Gao, H.Y., et al. (2020) Formation of Multilayer Interfaces and the Load Transfer in Graphene Nanoplatelets Reinforced Al matrix Composites. Materials Characterization, 159, Article ID: 110018. [Google Scholar] [CrossRef] 
[26] Yu, Z., Yang, W., Zhou, C., et al. (2019) Effect of Ball Milling Time on Graphene Nanosheets Reinforced Al6063 Composite Fabricated by Pressure Infiltration Method. Carbon, 141, 25-39. [Google Scholar] [CrossRef] 
[27] Xiong, B.W., Liu, K., Xiong, W., et al. (2020) Strengthening Effect Induced by Interfacial Reaction in Graphene Nanoplatelets Reinforced Aluminum Matrix Composites. Journal of Alloys and Compounds, 845, Article ID: 156282. [Google Scholar] [CrossRef] 
[28] Guo, B.S., Chen, B., Zhang, X.M., et al. (2018) Exploring the Size Effects of Al4C3 on the Mechanical Properties and Thermal Behaviors of Al-Based Composites Reinforced by SiC and Carbon Nanotubes. Carbon, 135, 224-35. [Google Scholar] [CrossRef] 
[29] Jiang, Y.Y., Tan, Z.Q., Fan, G.L., et al. (2020) Nucleation and Growth Mechanisms of Interfacial Carbide in Graphene Nanosheet/Al Composites. Carbon, 161, 17-24. [Google Scholar] [CrossRef] 
[30] 李宁, 杜晓明, 刘凤国. 石墨烯镀铜对铝基复合材料结构与性能的影响[J]. 沈阳理工大学学报, 2021, 40(4): 73-77+87.
[31] Wu, Q.J., Guo, Z.H., Li, N., et al. (2021) Titanium Dioxide Coated Graphene Prepared by Pressure Sintering as Reinforcement in Aluminum Matrix Composites. Rare Metal Materials and Engineering, 50, 3068-3075.
[32] Wang, C.Y., Su, Y.S., Ouyang, Q.B., et al. (2021) Enhanced Mechanical Behavior and Fabrication of Graphite Flakes Covered by Aligned Graphene Nanoplatelets Reinforced 2A12 Aluminum Composites. Vacuum, 188, 110150. [Google Scholar] [CrossRef] 
[33] Zheng, Z., Zhong, S.J., Zhang, X.X., et al. (2020) Graphene Nano-Platelets Reinforced Aluminum Composites with Anisotropic Compressive Properties. Materials Science and Engineering: A, 798, Article ID: 140234. [Google Scholar] [CrossRef] 
[34] 田锭坤. 碳纳米相定向排列增强铜基复合材料研究[D]: [硕士学位论文]. 秦皇岛: 燕山大学, 2019.

为你推荐